airtraffic

Author Topic: Headset fails and coincidentally the door blows open: A story and short clip  (Read 20080 times)

Offline KSYR-pjr

  • Hero Member
  • *****
  • Posts: 1722
I thought some here might appreciate this anecdote and audio clip, which is a testament to how a few seemingly small incidents can converge to quickly become a big distraction while flying. 

I have been commuting to Buffalo, NY, for work just about every week since February 2005 in a '73 Bonanza V35B.   Two Sunday nights ago, I was within Buffalo approach's airspace at about 50 miles from the airport at 4,000 feet MSL, when the batteries of my active noise reduction (ANR) headsets quit.  These headsets work very well at reducing cockpit noise when the ANR is working, but do a poor job when the ANR doesn't work.  Consequently, it became harder to hear ATC so I turned up the radio and went about fishing out a couple of AA batteries from my bag while the autopilot handled the task of keeping the aircraft level and on course.

In the dark of the cockpit I made my best guess at inserting the batteries but guessed incorrectly, for the ANR would not power up.  I had just opened the battery pack to try again when suddenly there was a loud, BOOM, as the latch of the passenger door completely released and the door blew open.  The shoulder belt that had been hanging behind the empty passenger seat was sucked out of the noticeable opening and the buckle began banging rapidly against the top of the fuselage.  Had the strap's other buckle not caught on the strap that hung from the ceiling, this shoulder belt would have departed the aircraft and descended into oblivion somewhere over the farm fields of western NY.

At the same instant that happened, the AP, which uses static pressure from within the cockpit to assist in determining level flight, suddenly commanded an approximate 1,200 foot a minute climb due to the pressure drop caused by the open door.

Now, I have had this door open (tricky latch) and even a passenger window in the back open (thanks to a mechanic opening it and not fully locking it closed, followed by my failure to check it) during flight in this aircraft before, but in the past episodes the latch partially held the door to the frame and only the cabin noise increased.  Of course, the ANR headsets also did their job to reduce the noise so it was a complete non-event.  This time was different.   I had no ear protection and the door was literally swinging about 4 inches (10cm) away from the frame.  So much for the slipstream keeping it pressed closed, despite an indicated airspeed of about 165 knots.  Of course it was now very windy in the cockpit and that wind was doing all it could to blow my non-working headsets off my head.  Fortunately the outside air temperature was +16 celcius, warm enough that the temperature was not a further distraction.

The first order of business was to release the AP and level the aircraft.  Once I was satisfied that I was positively controlling the aircraft, I cleared the seat next to me of all objects, including my bag and book of approach plates, since I deduced that the next annoyance could easily be a cockpit full of blowing papers.

I then made one attempt at slamming the door, but that was fruitless as the door latch wouldn't catch.   With a moment to slow my heart rate, I called ATC to inform them of the problem and to also request a straight approach, which would get me down quicker.

The short clip is somewhat routine, but I assure you it was very exciting in the cockpit during those moments.  The rest of the flight I spent concentrating on flying the aircraft while recollections of similar tales that ended in dead pilots and destroyed aircraft filled my thoughts.






Offline dave

  • Site Founder
  • Administrator
  • Hero Member
  • *****
  • Posts: 4593
    • LiveATC.net
Nice one - and nice handling of the "incident."  The great thing about doors popping open is that the plane still flies, as long as the pilot keeps his act together.

Incidentally, I had the door pop open of an A36 Bonanza many months ago with outside air temperate a bit cooler than +16C.  Brrr.  This happened on a climb through 4,000' for 7,000' just north of Philadelphia, after departing KPNE.  My passenger (my girlfriend) did a fine job of holding the door steady but her nerves were a little shot.

I opted to land in Allentown - we got down with no incident, closed the door, and taxied back to the active.  Allentown Approach was cool enough to even keep our full route clearance back to Nashua, NH in the system - Tower recleared us while we taxied and then cleared us for takeoff.

It was my first door pop and I hope it will be my last - but you never know.  All you can do is fly the airplane and stay calm.

Nice work, Peter!

Dave

Offline Jason

  • Hero Member
  • *****
  • Posts: 1260
  • CFI/CFII
Hi Peter,

Bravo-Zulu on handling the distraction very professionally!  Like dave said, the great thing about the door popping open in flight is that the plane still flies just like it did with the door closed if the pilot just keeps cool and performs his/her #1 most important job -- flying the airplane.

Thanks for attaching the clip.  Despite the obvious distraction, you communicated very clearly to Approach and sounded great.

My grandfather who owns an A36 Bonanza makes sure he closes and latches the door on each and every flight (even if it means reaching over the co-pilot).  He's had the door come open in flight and although it's managed with a calm, professional attitude, it does make for an unecessary distraction and tries his best to avoid it.  Although I don't physically close the door on his A36, I sure have learned a whole lot about what someone may consider such a simple item.

Fly safe,
Jason

Offline flyer_d

  • Jr. Member
  • **
  • Posts: 55
Well done!  The first time I lost the charge on my ANR, I was climbing out from a controlled field (on a student solo).  I suddenly couldn't hear anything, including the tower calling me.

Also -- you may want to file a NASA report, depending on the amount of the altitude excursion, to protect yourself.

Offline KSYR-pjr

  • Hero Member
  • *****
  • Posts: 1722
Thanks, all, for the good words.

Flyer-d: I hadn't thought about the NASA form but you are absolutely correct.  Off the top of my head I cannot remember what the grace period is to fill out the form but I have a few in my bag, so I will fish one out and hopefully be able to do so.

Offline Jason

  • Hero Member
  • *****
  • Posts: 1260
  • CFI/CFII
Thanks, all, for the good words.

Flyer-d: I hadn't thought about the NASA form but you are absolutely correct.  Off the top of my head I cannot remember what the grace period is to fill out the form but I have a few in my bag, so I will fish one out and hopefully be able to do so.


Hi Peter,

The grace period is 10 days, but I believe that only applies if you're submitting for the reason of legal immunity from a civil penalty and/or certificate suspension.  Click here for more info on that policy if you're interested.

Regards,
Jason

Jason

Offline dan9125

  • Full Member
  • ***
  • Posts: 239
Peter,
  Nice job staying calm and making a safe landing! Maybe you can turn that into an add for Eveready Energizer batteries.

  Dan

  http://audio.liveatc.net:8012/kbuf.m3u

Offline Neil

  • Jr. Member
  • **
  • Posts: 66
Pop the air latch window on the left side, and the door closes much easier...